Colostrum Quality Assessment in Dairy Goats: Use of an On-Farm Optical Refractometer.

Failure of passive immunity transfer is one of the main causes of increased susceptibility to infectious agents in newborn kids. To ensure successful transfer of passive immunity, kids need to be fed high-quality colostrum, containing an adequate concentration of IgG. This work evaluated the quality of colostrum obtained in the first 3 days postpartum from Malagueña dairy goats. The IgG concentration in colostrum was measured using an ELISA as a reference method, and it was estimated by optical refractometer. Colostrum composition in terms of fat and protein was also determined. The mean concentration of IgG was 36.6 ± 2.3 mg/mL, 22.4 ± 1.5 mg/mL and 8.4 ± 1.0 mg/mL on days 1, 2 and 3 after parturition, respectively. Brix values obtained using the optical refractometer were 23.2%, 18.6% and 14.1% for days 1, 2 and 3, respectively. In this population, 89% of goats produced high-quality colostrum with IgG concentrations of >20 mg/mL on the day of parturition, but this percentage declined dramatically over the following 2 days. The quality of the fresh colostrum estimated with the optical refractometer was positively correlated with those obtained using ELISA (r = 0.607, p = 0.001). This study highlights the importance of feeding first-day colostrum to newborn kids and demonstrates that the optical Brix refractometer is suitable for the on-farm estimation of IgG content in colostrum.

Optimisation of the predictive ability of NIR models to estimate nutritional parameters in elephant grass through LOCAL algorithms.

Elephant grass is a tropical forage widely used for livestock feed. The analytical techniques traditionally used for its nutritional evaluation are costly and time consuming. Alternatively, Near Infrared Spectroscopy (NIRS) technology has been used as a rapid analysis technique. However, in crops with high variability due to genetic improvement, predictive models quickly lose accuracy and must be recalibrated. The use of non-linear models such as LOCAL calibrations could mitigate these issues, although a number of parameters need to be optimized to obtain accurate results. The objective of this work was to compare the predictive results obtained with global NIRS calibrations and with LOCAL calibrations, paying special attention to the configuration parameters of the models. The results obtained showed that the prediction errors with the LOCAL models were between 1.6 and 17.5 % lower. The best results were obtained in most cases with a low number of selected samples (n = 100-250) and a high number of PLS terms (n = 20). This configuration allows a reduced computation time with high accuracy, becoming a valuable alternative for analytical determinations that require ruminal fluid, which would improve the welfare of the animals by avoiding the need to surgically prepare animals to estimate the nutritional value of the feeds.

Welfare Quality® for dairy cows: towards a sensor-based assessment.

This Research Reflection addresses the possibilities for Welfare Quality® to evolve from an assessment method based on data gathered on punctual visits to the farm to an assessment method based on sensor data. This approach could provide continuous and objective data, while being less costly and time consuming. Precision Livestock Farming (PLF) technologies enabling the monitorisation of Welfare Quality® measures are reviewed and discussed. For those measures that cannot be assessed by current technologies, some options to be developed are proposed. Picturing future dairy farms, the need for multipurpose and non-invasive PLF technologies is stated, in order to avoid an excessive artificialisation of the production system. Social concerns regarding digitalisation are also discussed.

A Low-Cost IoT-Based System to Monitor the Location of a Whole Herd.

Animal location technologies have evolved considerably in the last 60 years. Nowadays, animal tracking solutions based on global positioning systems (GPS) are commercially available. However, existing devices have several constraints, mostly related to wireless data transmission and financial cost, which make impractical the monitorization of all the animals in a herd. The main objective of this work is to develop a low-cost solution to enable the monitorization of a whole herd. An IoT-based system, which requires some animals of the herd being fitted with GPS collars connected to a Sigfox network and the rest with low-cost Bluetooth tags, has been developed. Its performance has been tested in two commercial farms, raising sheep and beef cattle, through the monitorization of 50 females in each case. Several collar/tag ratios, which define the cost per animal of the solution, have been simulated. Results demonstrate that a low collar/tag ratio enable the monitorization of a whole sheep herd. A larger ratio is needed for beef cows because of their grazing behavior. Nevertheless, the optimal ratio depends on the purpose of location data. Large variability has been observed for the number of hourly and daily messages from collars and tags. The system effectiveness for the monitorization of all the animals in a herd has been certainly proved.

Evaluation of local approaches to obtain accurate near-infrared (NIR) equations for prediction of ingredient composition of compound feeds.

This research work investigated new methods to improve the accuracy of intact feed calibrations for the near-infrared (NIR) prediction of the ingredient composition. When NIR reflection spectroscopy, together with linear models, was used for the prediction of the ingredient composition, the results were not always acceptable. Therefore, other methods have been investigated. Three different local methods (comparison analysis using restructured near-infrared and constituent data [CARNAC]), locally weighed regression [LWR], and LOCAL) were applied to a large (N = 20 320) and heterogeneous population of non-milled feed compounds for the NIR prediction of the inclusion percentage of wheat and sunflower meal, as representative of two different classes of ingredients. Compared with partial least-squares regression, results showed considerable reductions of standard error of prediction values for all methods and ingredients: reductions of 59, 47, and 50% with CARNAC, LWR, and LOCAL, respectively, for wheat, and reductions of 49, 45, and 43% with CARNAC, LWR, and LOCAL, respectively, for sunflower meal. These results are a valuable achievement in coping with legislation and manufacture requirements concerning the labeling of intact feedstuffs.

Near-infrared reflectance spectroscopy for predicting amino acids content in intact processed animal proteins.

Near-infrared calibrations were developed for the instantaneous prediction of amino acids composition of processed animal proteins (PAPs). Two sample presentation modes were compared (ground vs intact) for demonstrating the viability of the analysis in the intact form, avoiding the need for milling. Modified partial least-squares (MPLS) equations for the prediction of amino acids in PAPs were developed using the same set of samples (N = 92 PAPs) analyzed in ground and intact form and in three cups differing in the optical window size. The standard error for cross validation (SECV) and the coefficient of determination (1-VR) values yielded with the calibrations developed using the samples analyzed in the intact form showed similar or even better accuracy than those obtained with finely ground samples. The excellent predictive ability (1-VR > 0.90; CV < 3.0%) obtained for the prediction of amino acids in intact processed animal proteins opens an enormous expectative for the on-line implementation of NIRS technology in the processing and marketing of these important protein feed ingredients, alleviating the costs and time associated with the routine quality controls.